2001 Malibu / Stalled / Hissing / Rattles
08 Malibu LT AC Erratic Operation
My AC is very erratic, At times it will run just fine. Most of the time I have to "play" with the controls to get it to work. Been to dealer many times and "they" can't find problem. Have changed control head, had AC refridgerant added still no solution. Strange symptom, on the 2nd start up of engine, AC will begin to work, hardly ever on the 1st engine start up.
Re: 08 Malibu LT AC Erratic Operation
You might want to have your local GM dealer check for any calibration updates to any of the following modules....ECM, BCM, and HVAC Control Head. If there is an available update to any of those modules, a reprogramming should fix your issue.
If there are no updates, this is the type of problem that a technician actually has to have 'happening' while he is checking the car out. Maybe the previous times you had it at the dealership, the A/C was working fine, and then of course there would be no way to find the problem if it's functioning correctly. Sounds like an odd problem, hopefully you get it figured out.
If there are no updates, this is the type of problem that a technician actually has to have 'happening' while he is checking the car out. Maybe the previous times you had it at the dealership, the A/C was working fine, and then of course there would be no way to find the problem if it's functioning correctly. Sounds like an odd problem, hopefully you get it figured out.
GM Dealer Technician For 18+ Years
In the automotive industry for 20+
In the automotive industry for 20+
2001 Malibu / Stalled / Hissing / Rattles
Hello! I'm a rookie DIYer looking for advice to my issue. Before I begin I did add water to my system, distilled so I kept it free of minerals. I'm losing coolant from 1 of the heater hoses , just a small amount it seems. So I know this needs replaced. Here is what happened:
I was driving to the local farmers market about 8 miles from home. Before leaving I topped off the distilled water and attempted to bleed air from the vale on top of the water pump, never got a stream of water. Just as I got to the intersection of the store my temp gauge went to the redline and the temp warning light came on, at this point I could hear what sounded like rattling coming from my engine bay. As I approached the stop light the car stalled and refused to start for the next ~30 minutes. I opened the hood and had smoke coming from the engine when I removed the Oil Cap, and I'm almost certain I heard some hissing from the rear of the motor. Once the engine cooled down it did start up, not as easy as before but it did start. I ended up limping it back home because I didn't have the $150 the tow service wanted, I'm disabled and have to live off of what most people make in a week.
***EDIT: Need to add in that I was only able to drive it for 5 minutes before needing to pull over and sit for 20-30 minutes and let it cool down before driving again. While limping it home.***
A few days went by , I went to check out my car by starting it and attempting to listen for any abnormal noises when trying to start it up, I thought I had blown my motor or something serious at least. It fired right up no issues, though I let it run til it warmed up again trying to reproduce the rattling and hissing. It never rattled or hissed, though I did not go for a quick spin.
In a few days time I will have my disability deposit and I was planning on buying a new surge tank, water pump, thermostat with 180F opening temp instead of 192F and 4 gallons of Dex-Kill. To see if my issue was the water boiling out of the system, it's possible as it has a low boiling point. I would like your opinions and advice please. The car shows 157k miles on it.
I was driving to the local farmers market about 8 miles from home. Before leaving I topped off the distilled water and attempted to bleed air from the vale on top of the water pump, never got a stream of water. Just as I got to the intersection of the store my temp gauge went to the redline and the temp warning light came on, at this point I could hear what sounded like rattling coming from my engine bay. As I approached the stop light the car stalled and refused to start for the next ~30 minutes. I opened the hood and had smoke coming from the engine when I removed the Oil Cap, and I'm almost certain I heard some hissing from the rear of the motor. Once the engine cooled down it did start up, not as easy as before but it did start. I ended up limping it back home because I didn't have the $150 the tow service wanted, I'm disabled and have to live off of what most people make in a week.
***EDIT: Need to add in that I was only able to drive it for 5 minutes before needing to pull over and sit for 20-30 minutes and let it cool down before driving again. While limping it home.***
A few days went by , I went to check out my car by starting it and attempting to listen for any abnormal noises when trying to start it up, I thought I had blown my motor or something serious at least. It fired right up no issues, though I let it run til it warmed up again trying to reproduce the rattling and hissing. It never rattled or hissed, though I did not go for a quick spin.
In a few days time I will have my disability deposit and I was planning on buying a new surge tank, water pump, thermostat with 180F opening temp instead of 192F and 4 gallons of Dex-Kill. To see if my issue was the water boiling out of the system, it's possible as it has a low boiling point. I would like your opinions and advice please. The car shows 157k miles on it.
Re: 2001 Malibu / Stalled / Hissing / Rattles
well, you have to start with, Where is the leak? Fix it first.
the cooling system builds up pressure as the coolant gets hot. Up to the pressure rating in the radiator cap. The excess pressure will go through the cap and fill the overflow reservoir. Then when the coolant cools down when the engine is off the two way radiator cap will allow the radiator to pull the coolant back into the radiator to keep it full. Dex-cool, if left in contact with air will dry and crystalize (those crystals can plug stuff up) Anyways, when you have a leak coolant will escape the closed system and when the engine cools and it should pull the coolant from the reservoir, it won't. It will pull air back into the system. (easier to pukk air through the opening where it leaked out that pull coolant through the valve in the radiator cap. So, every time you run your engine and then let it cool down you have less coolant in the system. Eventually, it's going to overheat because there isn't enough coolant to transfer the heat.
To run the engine so hot it shuts down is pretty bad. a lot of times that will cause damage to the head gasket. the symptoms may not show for a while but when the engine gets too hot the block and the heads don't expand at the same rate. That can disturb the seal the head gasket has. Then after a while that breakdown will start so show up with coolant leaking into the combustion chamber. Engine may run rough on first start up in the morning but clears up after running for a while. Eventually that roughness will last longer and longer as the leak gets worse. You will have coolant losses but no external leak shows up. (because the engine is burning it) when it's really bad it will show up as white smoke out of the tailpipe.
as far as the noises, you probably won't get those noises back until it overheats again. you can get hissing from steam escaping the system. Either through where it is leaking from or steam overpowering the radiator cap and going into the reservoir. You can get knocking from the thermostat opening and slamming shut as steam and coolant go through it. The engine can ping from pre-ignition when the cylinders get too hot. The motor oil starts to breakdown when the temperature gets too hot also.
you should have your cooling system pressure tested and fix all the external leaks you find. Sometimes, if the water pump leaks, it may not show up. The water pump seal will sometimes leak and sometimes won't. Look for coolant stains from the weep hole. After all the external leaks are sealed then you have to keep and eye on the coolant level and also check the level inside the radiator. The radiator should be filled to the top and the reservoir should be in the marked area on the reservoir. Don't just fill the reservoir and call it good. you need to verify that the radiator is full. You have to check it in the morning before you run the engine. If the reservoir stays in the normal range but the radiator goes low then you have another leak. It may be internal or an external leak you didn't take care of.
the cooling system builds up pressure as the coolant gets hot. Up to the pressure rating in the radiator cap. The excess pressure will go through the cap and fill the overflow reservoir. Then when the coolant cools down when the engine is off the two way radiator cap will allow the radiator to pull the coolant back into the radiator to keep it full. Dex-cool, if left in contact with air will dry and crystalize (those crystals can plug stuff up) Anyways, when you have a leak coolant will escape the closed system and when the engine cools and it should pull the coolant from the reservoir, it won't. It will pull air back into the system. (easier to pukk air through the opening where it leaked out that pull coolant through the valve in the radiator cap. So, every time you run your engine and then let it cool down you have less coolant in the system. Eventually, it's going to overheat because there isn't enough coolant to transfer the heat.
To run the engine so hot it shuts down is pretty bad. a lot of times that will cause damage to the head gasket. the symptoms may not show for a while but when the engine gets too hot the block and the heads don't expand at the same rate. That can disturb the seal the head gasket has. Then after a while that breakdown will start so show up with coolant leaking into the combustion chamber. Engine may run rough on first start up in the morning but clears up after running for a while. Eventually that roughness will last longer and longer as the leak gets worse. You will have coolant losses but no external leak shows up. (because the engine is burning it) when it's really bad it will show up as white smoke out of the tailpipe.
as far as the noises, you probably won't get those noises back until it overheats again. you can get hissing from steam escaping the system. Either through where it is leaking from or steam overpowering the radiator cap and going into the reservoir. You can get knocking from the thermostat opening and slamming shut as steam and coolant go through it. The engine can ping from pre-ignition when the cylinders get too hot. The motor oil starts to breakdown when the temperature gets too hot also.
you should have your cooling system pressure tested and fix all the external leaks you find. Sometimes, if the water pump leaks, it may not show up. The water pump seal will sometimes leak and sometimes won't. Look for coolant stains from the weep hole. After all the external leaks are sealed then you have to keep and eye on the coolant level and also check the level inside the radiator. The radiator should be filled to the top and the reservoir should be in the marked area on the reservoir. Don't just fill the reservoir and call it good. you need to verify that the radiator is full. You have to check it in the morning before you run the engine. If the reservoir stays in the normal range but the radiator goes low then you have another leak. It may be internal or an external leak you didn't take care of.
Browse "SIMILAR TOPICS" At The Bottom Of This Page.
-
- Similar Topics
- Replies
- Views
- Last post
-
-
New post 06 Equinox - Window Rattles at 70 MPH
by tperk100 » Thu Jan 24, 2019 4:55 pm » in Chevy Cars - 1 Replies
- 19121 Views
-
Last post by carriedi
Fri Jan 25, 2019 5:24 am
-
-
-
New post 2001 Chevy Malibu check engine code p0446
by bjjmerrill » Sat Sep 13, 2014 12:42 pm » in Chevy Cars - 1 Replies
- 19436 Views
-
Last post by carriedi
Sat Sep 13, 2014 3:44 pm
-
-
- 1 Replies
- 24278 Views
-
Last post by carriedi
Wed Apr 26, 2023 12:27 pm
-
- 2 Replies
- 17160 Views
-
Last post by tsc864
Sun Nov 23, 2014 12:13 pm
-
- 2 Replies
- 16202 Views
-
Last post by butchkaz
Wed Jul 30, 2014 4:46 pm